PURSUIT 3370 OFFSHORE Bedienungshandbuch

3370 OFFSHORE13370 OFFSHOREOWNER’S MANUAL921220July, 2004FISHING BOATS3901 St. Lucie Blvd.Ft. Pierce, Florida 34946

3370 OFFSHORE10THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE100If the boat becomes swamped and capsizes, you and your passengers should stay with the boat as long as youcan. It is much easier

3370 OFFSHORE10112.14 Trash DisposalTHE DISCHARGE OF PLASTIC TRASH OR TRASH MIXED WITH PLASTIC IS ILLEGALANYWHERE IN THE MARINE ENVIRONMENT. IT IS AL

3370 OFFSHORE102THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE103Chapter 13:ROUTINE MAINTENANCE13.1 GeneralBEFORE USING A CLEANING PRODUCT, REFER TO THE PRODUCT DIRECTIONS ANDSPECIFICATIONS.IF URETHA

3370 OFFSHORE104Do not allow the hull antifouling paint to contact the outboard motor. Most antifouling paints designed for hullbottoms contain c

3370 OFFSHORE105USE EXTREME CARE WHEN WALKING ON WET GELCOAT SURFACES AS THEY ARESLIPPERY.Stainless Steel HardwareWhen using the boat in saltwater, th

3370 OFFSHORE106YOU SHOULD CONTACT PURSUIT CUSTOMER RELATIONS BEFORE MAKING ANYMODIFICATIONS TO ALUMINUM FABRICATIONS. UNAUTHORIZED MODIFICATIONS

3370 OFFSHORE10713.3 Upholstery, Canvas and EnclosuresVinyl UpholsteryThe vinyl upholstery used on the exterior seats and bolsters, and for the headl

3370 OFFSHORE108The bimini top, side curtains, clear connector, back drop and aft curtain must be removed when trailering.Canvas enclosures are no

3370 OFFSHORE109A flow of air into the bilge compartment is provided by vents. Periodic inspection and cleaning of theventilation ducts is necessary

3370 OFFSHORE11Registration and NumberingFederal law requires that all undocumented vessels equipped with propulsion machinery be registered in thesta

3370 OFFSHORE110THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE111Chapter 14:SEASONAL MAINTENANCE14.1 Storage and Lay-upBefore Hauling:• Pump out the head. Flush the holding tank using clean soap, w

3370 OFFSHORE112BOATS CAN BE DAMAGED FROM IMPROPER LIFTING AND ROUGH HANDLING WHENBEING TRANSPORTED BY LIFT TRUCKS. CARE AND PROPER HANDLING PROC

3370 OFFSHORE113Preparing The Boat For Storage:• Remove the bilge drain plug(s), if installed.• Thoroughly wash the fiberglass exterior, especially th

3370 OFFSHORE114The shower/cabin drain sump system must be properly winterized. Clean debris from the drain and sump andflush for several minutes

3370 OFFSHORE115The air conditioner components must be properly winterized by following winterizing procedure in the airconditioner owner’s manual.The

3370 OFFSHORE116PLACING AN ELECTRIC OR FUEL BURNING HEATING UNIT IN THE BILGE AREA CANBE POTENTIALLY HAZARDOUS AND IS NOT RECOMMENDED.Proper stora

3370 OFFSHORE117• Clean and wash the boat.• Install all upholstery, cushions and canvas.After Launching:• Carefully check all water systems and the en

3370 OFFSHORE118THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE119GLOSSARY OF TERMSAft: In, near, or toward the stern of a boat.Aground: A boat stuck on the bottom.Amidships: In or toward the part

3370 OFFSHORE12USCG specifications and regulations relating to performance, construction, or materials. The equipmentrequirements vary according

3370 OFFSHORE120Bridge: The area from which a boat is steered and controlled.Bridge Deck: A deck forward and usually above the cockpit deck.Broa

3370 OFFSHORE121EPIRB: Emergency Position Indicating Radio Beacon. Operates as a part of a worldwide satellite distresssystem.Even Keel: When a boa

3370 OFFSHORE122Helm: The steering and control area of a boat.Hull: The part of the boat from the deck down.Inboard: A boat with the engine mou

3370 OFFSHORE123Moored: A boat secured with cables, lines or anchors.Mooring: An anchor permanently embedded in the bottom of a harbor that is used

3370 OFFSHORE124Rubrail: Railing (often rubber or hard plastic) that runs along the boat’s sheer to protect the hull when comingalongside docks,

3370 OFFSHORE125Swimming Ladder: Much the same as the boarding ladder except that it extends down into the water.Taffrail: Rail around the rear of t

3370 OFFSHORE126THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE127Appendix B:MAINTENANCE SCHEDULE AND LOGMAINTENANCEEach UseWeeklyMonthlyEach SeasonYearlyAs NeededenilretawehtwoleblluhnaelCXlluhtniapm

3370 OFFSHORE128HoursDate DealerService/RepairsMAINTENANCE LOG

3370 OFFSHORE129HoursDate DealerService/RepairsMAINTENANCE LOG

3370 OFFSHORE13TABLE OF CONTENTSIntroduction:Safety Information ...3

3370 OFFSHORE130HoursDate DealerService/RepairsMAINTENANCE LOG

3370 OFFSHORE131HoursDate DealerService/RepairsMAINTENANCE LOG

3370 OFFSHORE132HoursDate DealerService/RepairsMAINTENANCE LOG

3370 OFFSHORE133Appendix C:BOATING ACCIDENT REPORTFORM APPROVEDOMB NO.211-0010DEPARTMENT OFTRANSPORTATIONU.S. COAST GUARDC.G. 1865 (REV. 1/88)The oper

3370 OFFSHORE134If more than 3 fatalities and/or injuries, attach additional form(s)WAS VICTIM?[ ] Swimmer[ ] Non SwimmerDATE OFBIRTHADDRESSNAME

3370 OFFSHORE135Appendix D:Float Plan1. Name of person reporting and telephone number.2. Description of boat.Type Color TrimRegistration No. LengthNam

3370 OFFSHORE136THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE137Appendix E:TROUBLESHOOTINGGUIDE• Steering system is low on fluid. Fill and bleed system.• Steering system has air in it. Fill and bl

3370 OFFSHORE138ENGINE PROBLEMSThe engine is running too hot.The engine alternator is not charging properly.The engine suddenly will not operate o

3370 OFFSHORE139• The strainer on the intake scoop is clogged preventingthe water from getting to the pump. Put the boat inreverse to clean the strai

3370 OFFSHORE14Chapter 4: Electrical System4.1 General ...

3370 OFFSHORE140THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE15Chapter 8: Ventilation System8.1 Cabin Ventilation ...618.2 W

3370 OFFSHORE16Chapter 12: Operation12.1 General ...8912.2

3370 OFFSHORE17Chapter 1:PROPULSION SYSTEM1.1 GeneralThe Pursuit 3370 Offshore is designed to be powered with twin 2-cycle or 4-cycle outboard motors.

3370 OFFSHORE18DO NOT PAINT THE OUTBOARD MOTORS WITH ANTIFOULING PAINTS DESIGNED FORBOAT HULLS. MANY OF THESE PAINTS CAN CAUSE SEVERE DAMAGE TO T

3370 OFFSHORE191.5 PropellersThe propellers convert the engine’s power into thrust. They come in a variety of styles, diameters and pitches.The one t

3370 OFFSHORE2THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE20Fuel GaugeThe fuel gauge indicates the amount of fuel in the fuel tanks. The fuel gauge switch, located on the helm,is used to sw

3370 OFFSHORE21Chapter 2:HELM CONTROL SYSTEMS2.1 GeneralThe helm controls consist of three systems: the engine throttle and shift controls, the stee

3370 OFFSHORE22The neutral safety switches should be tested periodically to ensure that they are operating properly. To testthe neutral safety sw

3370 OFFSHORE23Extinguishing System section in the Safety Equipment chapter of this owner's manual. Also read the automaticfire extinguisher own

3370 OFFSHORE242.8 Trim TabsThe trim tabs are recessed into the hull on the transom.Switches are used to control the trim tabs. The switches arel

3370 OFFSHORE25INSPECT AND MAINTAIN STEERING SYSTEM REGULARLY. DO NOT ATTEMPT CON-TROL ADJUSTMENTS UNLESS YOU ARE FAMILIAR WITH SERVICING CONTROL SYS

3370 OFFSHORE26THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE27Chapter 3:FUEL SYSTEM3.1 GeneralThe fuel system used in Pursuit boats is designed to meet or exceed the requirements of the U.S. Coas

3370 OFFSHORE28Fuel FillsA fuel fill deck plate is located on each gunwale and is marked “GAS” or"DIESEL" when equipped with an optiona

3370 OFFSHORE29Fuel withdrawal lines are equipped with anti-siphon valves where the lines attach to the fuel tanks. Thesevalves prevent gasoline from

3370 OFFSHORE3SAFETY INFORMATIONYour Owner’s Manual has been written toinclude a number of safety instructions to assure the safeoperation and mainte

3370 OFFSHORE30The diesel fuel withdrawal is equipped with an “ON/ OFF” valve located on the top of the fuel tank belowthe inspection plate in the

3370 OFFSHORE31ESTIMATE HOW MUCH FUEL IS NEEDED AND AVOID OVER FILLING THE TANK.SPILLED FUEL CAN CAUSE A FIRE OR AN EXPLOSION. MAKE SURE YOU DO NOTSP

3370 OFFSHORE32The age of gasoline can affect engine performance. Chemical changes occur as the gasoline ages that can causedeposits and varnish

3370 OFFSHORE33Chapter 4:ELECTRICAL SYSTEM4.1 GeneralYour Pursuit is equipped with AC and 12-volt DC electrical systems. The AC system can draw cur

3370 OFFSHORE344.3 DC Distribution SystemThe battery switches are part of an integrated DC power distribution system that contains several compone

3370 OFFSHORE35Heavy Duty Circuit Breaker: Used to protect the windlass circuit.Heavy Duty Distribution Stud: One or more of these may be used to di

3370 OFFSHORE36Windlass (Optional)Push the red button to open the circuit breaker. To reset or turn the circuit breaker on, rotate the black leve

3370 OFFSHORE37Aft Bilge PumpActivates the aft bilge pump which is installed in the aft bilge under the fish box. Depressing the switch willactivate

3370 OFFSHORE38Acc2This is open and held for future additional accessories not to exceed 10 amps.Trim Tab SwitchLocated on the lower right of the

3370 OFFSHORE39CABIN DC BREAKER PANELThe following are descriptions of the accessories controlled by the cabin breaker panel. These devices areprotec

3370 OFFSHORE4THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE40CARBON MONOXIDE IS A LETHAL, TOXIC GAS THAT IS COLORLESS AND ODORLESS.IT IS A DANGEROUS GAS THAT WILL CAUSE DEATH IN CERTAIN LEVELS

3370 OFFSHORE41HEAD COMPARTMENT PANELHolding Tank MaceratorThe holding tank overboard discharge macerator switchpanel is located in the head compartme

3370 OFFSHORE42TO REDUCE THE RISK OF ELECTRICAL SHOCK IN WET WEATHER, AVOID MAKINGCONTACT WITH THE SHORE CABLE OR MAKING A CONNECTION TO A LIVE SH

3370 OFFSHORE43DISCONNECTING PROCEDURE FOR SHORE POWER CONNECTIONTurn the main breaker on the AC paneland the disconnect switch on the docksideoutlet

3370 OFFSHORE44RefrigeratorSupplies AC electrical current directly to the optional refrigerator when AC power is available and chosenover the 12-v

3370 OFFSHORE45GFI OUTLETS DO NOT PROVIDE 100% PROTECTION FROM ELECTRIC SHOCK. EVENTHOUGH GROUND FAULT INTERRUPTERS PROVIDE PROTECTION BY REDUCING EX

3370 OFFSHORE46Generators charge the battery just enough to compensate for the DC electrical current the engine requires tooperate. Therefore, it

3370 OFFSHORE47Check all below deck wiring to be sure it is properly supported, that the insulation is sound, and that thereare no loose or corroded t

3370 OFFSHORE48CORROSION ALLOWED TO BUILD ON THE ELECTRICAL CONNECTORS CAN CAUSE APOOR CONNECTION RESULTING IN SHORTS, GROUND FAULTS OR POOR GROUN

3370 OFFSHORE49Chapter 5:FRESH WATER SYSTEM5.1 GeneralThe fresh water system consists of a potable water tank, distribution lines and a distribution

3370 OFFSHORE5BOAT INFORMATIONPlease fill out the following information section and leave it in your PursuitOwner’s Manual. This information will be

3370 OFFSHORE50DO NOT ALLOW THE FRESH WATER PUMP TO RUN DRY. THE FRESH WATER PUMPWORKS ON DEMAND AND WILL NOT SHUT OFF AUTOMATICALLY WHEN THE TAN

3370 OFFSHORE51An automatic float switch in the shower sump controls the pump. The pump is protected by the shower sumpcircuit breaker. After shower

3370 OFFSHORE52THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE53Chapter 6:RAW WATER SYSTEM6.1 GeneralIn the raw or sea water systems, all water pumps are supplied by hoses connected to ball valves a

3370 OFFSHORE54ALWAYS TURN THE RAW WATER PUMP SWITCH TO THE “OFF” POSITION WHENLEAVING THE BOAT UNATTENDED.DO NOT RUN THE HIGH PRESSURE PUMP DRY F

3370 OFFSHORE556.4 Air Conditioning Pump (Optional)The air conditioner is self-contained and sea water cooled. An AC centrifugal raw water pump suppl

3370 OFFSHORE56THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE57Chapter 7:DRAINAGE SYSTEMS7.1 GeneralAll water is drained by gravity to overboard thru-hull fittings located in the hull sides above

3370 OFFSHORE58THE MANUAL BILGE PUMP SHOULD BEACTIVATED BRIEFLY EACH TIME THEBOAT IS USED. THIS WILL ENSURETHAT IT IS OPERATING PROPERLY.THE AUTO

3370 OFFSHORE597.6 Water System DrainsAll exterior sinks and livewells, provided with fresh or raw water, drain by gravity to overboard thru-hullsloca

3370 OFFSHORE6THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE60ALL DRAINS AND PUMPS MUST BE PROPERLY WINTERIZED BEFORE WINTER LAY-UP.NEVER USE HARSH CHEMICAL DRAIN CLEANERS IN MARINE DRAIN SYSTE

3370 OFFSHORE61Chapter 8:VENTILATION SYSTEM8.1 Cabin VentilationVentilation to the cabin area is provided by a deck hatch and opening port windows.Por

3370 OFFSHORE628.4 Bilge Compartment VentilationAll 3370 Offshore models are equipped with ventilation for the bilge compartment. A flow of air

3370 OFFSHORE63easily. Never use a dry cloth or glass cleaning solutions on acrylic glass . Use a soft cloth and mild soapand water for routine clea

3370 OFFSHORE64THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE65Chapter 9:EXTERIOR EQUIPMENT9.1 DeckRails and Deck HardwareThe rail system and hardware fittings have been selected and installed to

3370 OFFSHORE66THE ANCHOR MUST BE POSITIONED SO IT DOES NOT REST AGAINST THE HULLSIDES AND BE PROPERLY SECURED AT ALL TIMES WHEN IT IS STORED IN T

3370 OFFSHORE67WindshieldThe Pursuit 3370 Offshore is equipped with a one-piece vented fiberglasswindshield with tinted glass and built-in hand rails.

3370 OFFSHORE68Helm SeatThe helm seat is a pedestal seat that swivels and adjusts fore and aft. There are two levers and one tensionknob on the s

3370 OFFSHORE69Below Deck FishboxA fish box is located in the stern below the cockpit sole. It can be removed from the deck by grasping thetwo handle

3370 OFFSHORE7CERTIFICATIONS & SPECIFICATIONS(For Export Only)Manufacturer:NameAddressZip Code:Identification Numbers:Hull Identification NumberEn

3370 OFFSHORE70Stern SeatA fold down seat is built into the rear of the cockpit. To use the aft seat,grasp the lower edge of the seat and raise i

3370 OFFSHORE71When closing the door, make sure you push the door against the door jam with enough pressure to allow thelatch to secure the door. Whe

3370 OFFSHORE72NOTICENOTICETO PREVENT GEL CRACKING OR DAMAGE TO GUNWALES OR DECKS, SUPPORT EX-TENDING TO THE STRINGERS MAY BE REQUIRED. FIBERGLAS

3370 OFFSHORE73Chapter 10:INTERIOR EQUIPMENT10.1 Companion Way Steps and Aft BerthThe aft berth is located behind the steps. There are three access h

3370 OFFSHORE74The waste is transferred into the holding tank where it remains until it is pumped out by a waste dumping stationor the overboard m

3370 OFFSHORE7510.3 GalleyThe galley is equipped with storage and a fresh water sink with hot and cold faucets. Water is supplied to thesink by a 12-

3370 OFFSHORE7610.4 L-Lounge and TableThe L-lounge is on the starboard side of the cabin. There isa compartment below a hatch under the aft cushi

3370 OFFSHORE77Air locks can occur in the air conditioning water supply system at the time of launching. If your boat has beenrecently launched and w

3370 OFFSHORE78THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE79Chapter 11:SAFETY EQUIPMENT11.1 GeneralYour boat and outboard engines have been equipped with safety equipment designed to enhance th

3370 OFFSHORE8THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE8011.3 Neutral Safety SwitchEvery control system has a neutral safety switch incorporated into it. This device prohibits the engines

3370 OFFSHORE81IF ACTIVATION SHOULD OCCUR, IMMEDIATELY SHUT DOWN ALL ENGINES. TURNOFF ALL ELECTRICAL SYSTEMS, POWERED VENTILATION AND EXTINGUISH ALLS

3370 OFFSHORE82This device uses a micro controller to continuously measure and accumulate CO levels. Should a very highlevel of carbon monoxide e

3370 OFFSHORE83up of carbon monoxide in the human body over several hours causes headache, nausea and other symptomssimilar to food poisoning, motion

3370 OFFSHORE8411.7 First AidIt is the operator's responsibility to be familiar with the proper first-aidprocedures and be able to care for m

3370 OFFSHORE85Visual Distress Signals:All Pursuit boats used on coastal waters, the Great Lakes, territorial seas, and those waters connected directl

3370 OFFSHORE86Fire Extinguishers:At least one fire extinguisher is required on all Pursuit boats. Coast Guard approved fire extinguishers arehan

3370 OFFSHORE8711.9 Additional Safety EquipmentBesides meeting the legal requirements, prudent boaters carry additional safety equipment. This is par

3370 OFFSHORE88THIS PAGE WAS LEFT BLANKINTENTIONALLY

3370 OFFSHORE89Chapter 12:OPERATION12.1 GeneralBefore you start the engines on your Pursuit, you should have become familiar with the various compon

3370 OFFSHORE9Warranty and Warranty Registration CardsThe Pursuit Limited Warranty Statement is included with your boat. It has been written to be cl

3370 OFFSHORE90DECKS ARE SLIPPERY WHEN WET. WEAR PROPER FOOTWEAR AND USE EXTREMECAUTION ON WET SURFACES.12.2 Rules of the RoadAs in driving an au

3370 OFFSHORE91Overtaking SituationsWhen one motor boat is overtaking another motor boat,the boat that is being passed has the right of way. Theovert

3370 OFFSHORE92THERE MUST BE AT LEAST ONE PERSONAL FLOTATION DEVICE ON BOARD FOR EV-ERY PERSON ON BOARD AND ONE THROW-OUT FLOTATION DEVICE. CHECK

3370 OFFSHORE93• Be sure the emergency stop lanyard is attached to the operator and the stop switch.VAPORIZING LIQUID EXTINGUISHERS GIVE OFF TOXIC FUM

3370 OFFSHORE94• Avoid sea conditions that are beyond the skill and experience of you and your crew.MAKE SURE ONE OTHER PERSON ON THE BOAT IS INST

3370 OFFSHORE95• Check the bilge area for debris and excess water.• Fill the fuel tanks to near full to reduce condensation. Allow enough room in the

3370 OFFSHORE96• Be careful when using the trim tabs from the tower. The reaction of the trim tabs will be exaggeratedin the tower. Use small ta

3370 OFFSHORE97Dock lines are generally twisted or braided nylon. Nylon is strong and stretches to absorb shock. It also hasa long life and is soft

3370 OFFSHORE98Leaving a MooringStart the engines and let them warm up for several minutes before releasing the mooring line. The boat willalread

3370 OFFSHORE99stabilized, thoroughly inspect the boat for damage. Check below decks for leaks and the control systems forproper operation. Plug all